Quadra-Fire 7100FP Manuale del Proprietario

R www.quadrafire.com433-1390GSeptember 1, 2008DO NOT DISCARD THIS MANUALCAUTION• Important operating and maintenance instructions included.• Leave th

Page 10433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace3 Framing and Clearances A. Selecting Fireplace LocationSeveral options are availa

September 1, 2008433-1390GPage 117100FP EPA Woodburning FireplaceR B. ClearancesFigure 11.1 Clearances to Combustible MaterialsFire Risk• Comply wi

Page 12433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceC. Frame the FireplaceNOTE: Wiring for blowers must be done before framed enclosu

September 1, 2008433-1390GPage 137100FP EPA Woodburning FireplaceR Fire RiskDo not apply combustible finishing materials over any part of the front of

Page 14433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceE. Construct the ChaseA chase is a vertical boxlike structure built to enclose the

September 1, 2008433-1390GPage 157100FP EPA Woodburning FireplaceR A. Install the Outside Air KitThis fireplace will operate correctly only if adequat

Page 16433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceRisk of Smoke SpillageOutside air inlet must be located to prevent blockage from:

September 1, 2008433-1390GPage 177100FP EPA Woodburning FireplaceR Figure 17.1 Outside Convection Air PlacementOutlet blocked bysnow, leaves, etc.NO

Page 18433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceThe auxiliary convection lever allows you to choose where the convection air is co

September 1, 2008433-1390GPage 197100FP EPA Woodburning FireplaceR • Level the FireplaceLevel the fireplace side-to-side and front-to-back. Shim with

and Welcome to the Quadra-Fire Family!Hearth & Home Technologies welcomes you to our tradition of excellence! In choosing a Quadra-Fire appliance

Page 20433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceNOTE:• Chimney performance may vary.• Trees, buildings, roof lines and wind cond

September 1, 2008433-1390GPage 217100FP EPA Woodburning FireplaceR A. Chimney RequirementsVertical distances are measured from the base of the fire-pl

Page 22433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceC. Using Offsets/ReturnsTo bypass any overhead obstructions, the chimney may be of

September 1, 2008433-1390GPage 237100FP EPA Woodburning FireplaceR D. Assemble the Chimney SectionsAttach either a straight chimney section or an off

Page 24433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceF. Install the Ceiling Firestops• Mark and cut an opening in the ceiling for the

September 1, 2008433-1390GPage 257100FP EPA Woodburning FireplaceR G. Install the Attic Insulation ShieldAn insulation shield must be installed when

Page 26433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace A Gas Termination Wood or Fuel Oil Termination B 6 in. (152 mm) min.

September 1, 2008433-1390GPage 277100FP EPA Woodburning FireplaceR Figure 27.1 Ceiling/Attic ConstructionFire Risk• Must maintain 2 in. (51 mm) ai

Page 28433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceNAILFLASHINGPLATECHIMNEYTHIMBLEEXTENSIONSCREWFLASHINGTHIMBLEADJUSTABLE EXTENSION H

September 1, 2008433-1390GPage 297100FP EPA Woodburning FireplaceR Termination Cap Storm Collar Slope Downward Turn-down Drip Edge Chase (Chimney) 2

Section 1: Listing and Code ApprovalsA. Appliance Certification . ...4B. Mobile Home Approved ...4C. Glass Specifica

Page 30433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceStorm Collar Flashing Collar Top of Pipe 14-1/2 in. (368mm) max. 1-1/2 in. (38 mm)

September 1, 2008433-1390GPage 317100FP EPA Woodburning FireplaceR A. Blower Replacement 7 Replacement Parts Screwdriver SlotScrewsUnplug wire harne

Page 32433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceB. Baffle Removal and Installation1. Remove all ash from firebox, and extinguish a

September 1, 2008433-1390GPage 337100FP EPA Woodburning FireplaceR This kit is tested and safe when installed in accordance with this installation ma

Page 34433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceINSTALLATION1. Remove the knockout or cover plate from the top of the fireplace and

September 1, 2008433-1390GPage 357100FP EPA Woodburning FireplaceR NOTE: Secure the duct so that clearance to the fire-place outer wrap is maintained

Page 36433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceRemove 2 screws and pry open access door.1. Remove both doors, fascia and brick.

September 1, 2008433-1390GPage 377100FP EPA Woodburning FireplaceR Timer PlateRotate assembly up and out through access doorArm must be in this posit

Page 38433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace8 Finishing A. Hearth ExtensionA hearth extension must be installed with all firepl

September 1, 2008433-1390GPage 397100FP EPA Woodburning FireplaceR Figure 39.1 Positioning the Protective Metal Hearth StripsFire Risk• Metal heart

Page 4433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace1 Listing and Code Approvals A. Appliance CertificationThis appliance is approved f

Page 40433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceFascia Outer Can Flange Ember Strip (Seal gap with High temp, noncombustible seala

September 1, 2008433-1390GPage 417100FP EPA Woodburning FireplaceR Seal with non-combustiblesealantC. Position the Hearth ExtensionPosition and se

Page 42433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceTOOLS NEEDED: Powered drill with #2 Phillips head bit; caulk-ing gun.1in. (25mm) O

September 1, 2008433-1390GPage 437100FP EPA Woodburning FireplaceR Figure 43.1 Mantel Specifications60 in.(1524mm)MantelClearances are from bottom of

Page 44433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace9 Operating Instructions Do not over-fire.Over-firing may ignite creosote or will da

September 1, 2008433-1390GPage 457100FP EPA Woodburning FireplaceR C. General InformationFireplaces, as well as other woodburning appliances, have be

Page 46433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceMoisture contentRegardless of which species of wood you burn, the single most impo

September 1, 2008433-1390GPage 477100FP EPA Woodburning FireplaceR Storing WoodSplitting wood before it is stored reduces drying time. The following

Page 48433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceFor maximum operating efficiency with the lowest emissions, follow these operating

September 1, 2008433-1390GPage 497100FP EPA Woodburning FireplaceR I. Starting a FireBefore lighting your first fire in the fireplace, make cer-tain th

September 1, 2008433-1390GPage 57100FP EPA Woodburning FireplaceR Improper installation, adjustment, alteration, ser-vice or maintenance can cause in

Page 50433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceCORRECT POSITIONINCORRECT POSITIONSFirebox damage due to improper baffle place-ment

September 1, 2008433-1390GPage 517100FP EPA Woodburning FireplaceR K. Outside AirA source of air (oxygen) is required in order for combustion to take

Page 52433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceN. Blower OperationInstructions with Blower Override Switch in manual posi-tion.N

September 1, 2008433-1390GPage 537100FP EPA Woodburning FireplaceR 10 Troubleshooting This fireplace will operate correctly only if adequate ventila-t

Page 54433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceAnother appliance in home also exhaustingair (furnace, fan, dryer, etc.)?Air regis

September 1, 2008433-1390GPage 557100FP EPA Woodburning FireplaceR Diagnostic Question Possible Causes of Condition SolutionsAre the air controls ope

Page 56433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace4. I don’t get enough/any heat. What can I do about it?Diagnostic Question Possi

September 1, 2008433-1390GPage 577100FP EPA Woodburning FireplaceR 11 Maintenance and Servicing the Fireplace A. General MaintenanceInspection: Ins

Page 58433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace2. Disposal of AshesFire Risk.Disposal of AshesWARNING• Ashes should be placed i

September 1, 2008433-1390GPage 597100FP EPA Woodburning FireplaceR 4555 55555355555222224555311C. Brick ReplacementThe firebox of your fireplace is lin

Page 6433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace2 Getting Started A. Design and Installation ConsiderationsC. Negative PressureDraf

Page 60433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceE. Maintenance Task ListInspect Maintenance TasksScreens 1. Assess condition of sc

September 1, 2008433-1390GPage 617100FP EPA Woodburning FireplaceR Date of Service Performed By Description of ServiceF. Service And Maintenance Log

Page 62433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplace12 Reference Materials A. Fireplace DimensionsCLGHBlower Electric Access(right sid

September 1, 2008433-1390GPage 637100FP EPA Woodburning FireplaceR B. Chimney ComponentsRF370 - Roof FlashingFlat to 6/12 Pitch12 in.(305 mm)24-5/8 i

Page 64433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceAS8Straight AtticInsulation Shield24 in.(610 mmSL3 - Chimney StabilizerInside Diam

September 1, 2008433-1390GPage 657100FP EPA Woodburning FireplaceR Figure 65.1 - Door, Glass & Door Handle Assembly303133632237386742334394034355

Page 66433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceD. Fireplace DiagramFigure 66.1 - Fireplace Diagram1011121314151617181920252627212

September 1, 2008433-1390GPage 677100FP EPA Woodburning FireplaceR IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on

Page 68433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceItem #Part DescriptionAlphabetical OrderSKUOuter Can Cover Plate480-1300Outer Can

September 1, 2008433-1390GPage 697100FP EPA Woodburning FireplaceR G. Warranty PolicyHearth & Home Technologies LIMITED WARRANTYHearth & Home

September 1, 2008433-1390GPage 77100FP EPA Woodburning FireplaceR The 7100FP Fireplace requires a minimum flue draft of -0.10 inches of water column o

Page 70433-1390GSeptember 1, 2008R 7100FP EPA Woodburning Fireplacemental conditions, inadequate ventilation or drafting caused by tight sealing cons

September 1, 2008433-1390GPage 717100FP EPA Woodburning FireplaceR This page intentionally left blank.

R Hearth & Home Technologies1445 North HighwayColville, WA 99114Division of HNI INDUSTRIES433-1390GSeptember 1, 2008Page 72CONTACT INFORMATION:P

Page 8433-1390GSeptember 1, 2008R 7100FP EPA Woodburning FireplaceFigure 8.1 Typical Fireplace SystemNote: Junction box should be installed during

September 1, 2008433-1390GPage 97100FP EPA Woodburning FireplaceR Before beginning the installation be sure the following tools and building supplies